concrete making by replacing aggregate using river sand

Replacement of River Sand by M Sand Concrete – IJERT

2019-11-22 · Sand is used as fine aggregate in concrete. Natural river sand is the most preferred choice as a fine aggregate material. River sand is a product of natural weathering of rocks over a period of millions of years. It is mined from the river beds and sand

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase in construction activities leads to acute shortage of conventional construction materials. It is conventional that sand is being used as fine aggregate in concrete. For the past two years, the escalation in cost of sand due to administrative restrictions in India, demands comparatively greater cost at around two to three times the cost for crusher waste even in places where river sand

Replacement of Fine Aggregate by M-Sand - IJSTE

2017-7-7 · 3) Replacement of 15% Natural River sand by manufactured sand yielded good split tensile strength for M20 grade concrete. 4) Replacing natural sand by manufactured sand induces higher strength in concrete than the conventional concrete. 5) Better control over

EXPERIMENTAL INVESTIGATION ON CONCRETE BY

2019-4-21 · using crushed stone dust as an alternative for replacing fine aggregate. It not only reduces the cost of construction but also provides a solution for the disposal problem of stone dust, at the same time it avoids the stone dusts waste impact on environment. 1.1 Research Significance Usually while making concrete and motor river sand is used

A review on Properties of Sustainable Concrete using ...

2016-7-10 · The granite dust exhibits appearance and particle size distribution nearly similar to that of natural fine aggregate i.e. river sand. Such properties make it a viable product as fine aggregate in concrete. Therefore its suitability as sand replacement and its effect on the fresh, hardened and durability properties of concrete have been assessed ...

Developing Concrete using Sea Shell as a Fine Aggregate

2017-4-5 · Developing Concrete using Sea Shell as a Fine Aggregate Ms. V. Mohanalakshmi Ms. S. Indhu PG Student PG Student ... we have planned to replace the river sand which is widely used in construction by sea shell. Sea shell is the dead remain of the marine organism. We have replaced the sea shell after grinding it to the maximum size of 4.75 mm.

An experimental study of replacing conventional coarse ...

2020-1-1 · Saravanan and Jagadesh (2015) presented a detailed study on the strength of M40 Grade concrete by partial replacement of river sand with manufactured artificial sand. The compressive strength of concrete was found to increase compared with the conventional concrete with river sand when 0.5% of Cera Chem Plasticizer is used as an admixture.

(PDF) REPLACEMENT OF NATURAL SAND IN CONCRETE

This is the situation for the construction industry today and most will agree that it will not change dramatically in the foreseeable future. Crushed aggregate, bottom ash, foundry sand and various...

(PDF) Study on Concrete by replacing cement by SCBA

cement. In recent days the demand for river sand is that would potentially be used as a cement replacement Hence the practice material. of replacing river sand with M-Sand and partial replacing production of sugarcane is over 1500 million tons.

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15 · natural sand in concrete. Two sample of M20 mixes were prepared using Grade-43 OPC, one with quarry dust and another by marble sludge powder combination. It was concluded that quarry dust and marble sludge powder combination as fine aggregate in concrete was recommended. 3. Chandana Sukesh (2013) in his study published in the

Experimental Study on Concrete by Replacing Fine

2020-5-29 · Cement 30Min Table B. Fine aggregate (M - SAND) Manufactured sand is a substitute of river sand for construction purposes. M sand produced from hard granite stone by crushing. The crushed sand is of cubical shape with grounded edges, washed and graded to as a construction material. The size of M-sand is less than 4.75 mm.

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4 · as a good substitute for natural river sand giving higher strength at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water.

Replacement of Fine Aggregate by M-Sand - IJSTE

2017-7-7 · 3) Replacement of 15% Natural River sand by manufactured sand yielded good split tensile strength for M20 grade concrete. 4) Replacing natural sand by manufactured sand induces higher strength in concrete than the conventional concrete. 5) Better control over

EXPERIMENTAL INVESTIGATION ON CONCRETE BY

2019-4-21 · using crushed stone dust as an alternative for replacing fine aggregate. It not only reduces the cost of construction but also provides a solution for the disposal problem of stone dust, at the same time it avoids the stone dusts waste impact on environment. 1.1 Research Significance Usually while making concrete and motor river sand is used

A review on Properties of Sustainable Concrete using ...

2016-7-10 · The granite dust exhibits appearance and particle size distribution nearly similar to that of natural fine aggregate i.e. river sand. Such properties make it a viable product as fine aggregate in concrete. Therefore its suitability as sand replacement and its effect on the fresh, hardened and durability properties of concrete have been assessed ...

EXPERIMENTAL STUDY OF CONCRETE WITH COPPER

2019-3-6 · Abstract - In order to avoid using natural river sand. An alternative material is proposed to the strength of the concrete by replacing of fine aggregate. Partially by waste material like copper slag which is an environmental waste. To make us of these material without sacrifice the strength and durability of the concrete structure.

Experimental Study on Strengthening Of Concrete by ...

2017-7-28 · Experimental Study On Strengthening Of Concrete By Replacing Seashell And Flyash ... 2.1.2 Fine Aggregate: Natural river sand with fraction passing through 4.75mm sieve and on 150µm sieve was used and tested as per IS: 2386-1983. The important properties tested for the aggregate

Study on Properties of Concrete using Robosand as Fine ...

2017-9-26 · Sand is basic concrete making construction material required in large quantities. Robosand is one among such materials to replace river sand, which can be used as an alternative fine aggregate in mortars and concrete. In this present research work, M20 and M30 grades of concrete are used as reference mixes.

Experimental Studies on Properties of Concrete and

2019-11-25 · the required qualities for use in concrete. Sand is basic concrete making construction material required in large quantities. Robo sand is one of the most used among such materials to replace river sand, which can be used as an alternative to fine aggregate in cement mortar and concrete.

(PDF) Potential Small Aggregate of Concrete and Mortal ...

Potential Small Aggregate of Concrete and Mortal Making from Marine Sand: A Case Study of Quang Nam Coastal Plain in Vietnam, pp.148-154 August 2021 Conference: IVCST 2021, Thailand

Experimental Study on Concrete by Replacing Fine

2020-5-29 · Cement 30Min Table B. Fine aggregate (M - SAND) Manufactured sand is a substitute of river sand for construction purposes. M sand produced from hard granite stone by crushing. The crushed sand is of cubical shape with grounded edges, washed and graded to as a construction material. The size of M-sand is less than 4.75 mm.

EXPERIMENTAL INVESTIGATION ON CONCRETE BY

2019-4-21 · using crushed stone dust as an alternative for replacing fine aggregate. It not only reduces the cost of construction but also provides a solution for the disposal problem of stone dust, at the same time it avoids the stone dusts waste impact on environment. 1.1 Research Significance Usually while making concrete and motor river sand is used

Study on Properties of Concrete using Robosand as Fine ...

2017-9-26 · Sand is basic concrete making construction material required in large quantities. Robosand is one among such materials to replace river sand, which can be used as an alternative fine aggregate in mortars and concrete. In this present research work, M20 and M30 grades of concrete are used as reference mixes.

Developing Concrete using Sea Shell as a Fine Aggregate

2017-4-5 · Developing Concrete using Sea Shell as a Fine Aggregate Ms. V. Mohanalakshmi Ms. S. Indhu PG Student PG Student ... we have planned to replace the river sand which is widely used in construction by sea shell. Sea shell is the dead remain of the marine organism. We have replaced the sea shell after grinding it to the maximum size of 4.75 mm.

Experimental Study on Strengthening Of Concrete by ...

2017-7-28 · Experimental Study On Strengthening Of Concrete By Replacing Seashell And Flyash ... 2.1.2 Fine Aggregate: Natural river sand with fraction passing through 4.75mm sieve and on 150µm sieve was used and tested as per IS: 2386-1983. The important properties tested for the aggregate

MECHANICAL PROPERTIES OF RECYCLED AGGREGATE

2019-4-21 · Keywords: - recycled aggregate, Bentonite, Robo sand, Natural aggregate, Super Plasticizer. -----***----- 1. INTRODUCTION About 7.5 billion cubic meters of concrete is produced each year, more than one cubic meter for every person on the Earth. Production of concrete requires a host of material resources in terms of cement, sand and aggregates.

EXPREMENTAL INVESTIGATION OF CONCRETE IN

2020-8-16 · EXPREMENTAL INVESTIGATION OF CONCRETE IN PARTIAL REPLACEMENT OF CEMENT AND FINE AGGREGATE USING GGBS AND M SAND K.P.Ravikumar1, A.Ayyappan2, P.Ajith kumar3, G.Jeya seelan4, M.Manoj kumar5, M. Mathan kumar6 1,2Assistant Professor, 3-6UG students Department of Civil Engineering, Shivani Engineering College, Tiruchirappalli-620009.

Experimental Study On Partial Replacement Of Cement

2015-6-3 · sand in concrete. The detailed experimental investigation is came to study the effect of partial replacement of cement by Fly Ash (FA) and fine aggregate by quarry sand with using admixture in concrete.The huge quantity of concrete is consumed by construction industry all over the world. In India, the conventional concrete is produced using ...

Compressive Resistance of Environmental Concrete Using

This paper presents the production of enviromental concrete using fine aggregate and fly ash to reduce bad influences on environment. The excessive exploition of traditional sand in Mekong Delta rivers has recently caused serious landslides sweeping away a large area and making. Therefore, using alternative materials - fine aggregate to replace river sand - is very important and urgent.

Strength Analysis of Concrete by Using Iron Slag as a ...

Fine aggregates: Locally available clean river sand passing through the IS-480 sieves have been used. The results of sieve analysis conducted as per the specification of code IS: 383 -1970.The fineness modulus of fine aggregate is 3.276.Fine aggregates like river sand , Moran are used in mix proportion of concrete.

Copyright © 2020.Company name All rights reserved.SiteMap